The Sikorsky VS-44 Flying Boat

The VS-44, having had both military and civil application, had been Sikorsky's largest—and last—flying boat, but had had a meager production run of only four.

Tracing its lineage to several previous amphibious designs, it had its first spark in the S-38.  Powered by two 420-hp Pratt and Whitney Wasp engines, the ten-passenger biplane, first flying in 1928 and attaining cruise speeds of about 100 mph, had been ordered by the US Navy and Pan American Airways.  Lindbergh inaugurated airmail service with the type between the US and the Panama Canal Zone the following year.  Operated by several other carriers, it enjoyed a production run of 110.

The succeeding, quad-engined, high-wing, boat-hulled S-40, ordered by Pan American in 1929 and destined to become the then-largest US aircraft, accommodated 40 passengers on 500-mile sectors, the first, designated "American Clipper," inaugurating service on November 19, 1931.  Its eventual fleet of three enabled it to pioneer Caribbean and South American routes.

The S-41, a larger version of the S-38 with a capacity of 14, had a production run of just seven.

Intended for transoceanic routes, the S-42, powered by four Pratt and Whitney engines driving reversible-pitch Hamilton Standard propellers, was designed to fill requirements for a larger-capacity, 2,500-mile, amphibious airliner cruising at 150 mph, although a reduced, 1,500-pound payload significantly increased its range capability.  First flying in 1934, it enabled Pan American to serve previously uncoverable Atlantic and Pacific segments with its fleet of ten.

The largest—and last—Sikorsky flying boat, incorporating technology developed by these earlier designs, arose from the Navy's requirement for a 3,450-mile patrol bomber to eclipse the range of its current PBY Catalinas.  The specification, detailed by the US Navy Bureau of Aeronautics' Design Proposal #137, stipulated a 200-mph speed, a crew complement of six, and four machine gun turrets.

The design, sequentially designated "S-44" by Sikorsky, and the only one which closely met the Navy's requirements, incorporated a high, all-metal, cantilever wing; four Pratt and Whitney, 700-hp Twin Wasp radials which drove constant-speed Hamilton Standard propellers; a .50-caliber machine gun in both its bow and tail turrets; and a .30-caliber machine gun in its two center turrets.  Although it could equally accommodate 4,000 pounds of bombs, the later specified, and more powerful, 1,050-hp R-1830-68 engines, coupled with 12-foot-diameter props, doubled this capacity.

A single prototype, for which a contract had been awarded on June 25, 1936, first flew a year later on August 13 from the Housatonic River near the Sikorsky factory in Stratford, and featured a 47,142-pound gross weight in bomber configuration and a 49,059-pound maximum weight in patrol guise.

The two-month flight test program, entailing 26.9 airborne hours, revealed several performance parameters, including a 640-fpm initial climb rate, a 62-mph stall speed, a 225-mph maximum speed at 10,000 feet, a 23,100-foot service ceiling, and a 4,545-mile range.

Delivered to Norfolk Naval Air Station on October 12, 1937, the XPBS-1 accumulated an additional 53.5 hours of test flying, during which rudder control force deficiencies were experienced, necessitating a return to the manufacturer for modifications.  Yet, despite the fact that Navy pilots expressed overall aircraft handling and performance satisfaction, the Navy itself abruptly canceled any further orders for the design, replacing it with the Coronado instead.  No reason was subsequently specified.

Thus relegated to transporting government officials and priority cargo, the single XPBS-1 operated for five years until it was damaged while landing in San Francisco Bay in 1942, incurring a log strike.  It was removed from Navy inventory with 1,367.5 hours in its logbook.

The design, however, had commercial application.  Pan American Airways' competitor, American Export Airlines (AEA), seeking a long-range, amphibious airliner for its own transatlantic passenger services, signed a contract for a civil version of the XPBS-1 designated "VS-44", the "VS" prefix reflecting the combined, but temporary, Chance Vought and Sikorsky factory operations, both divisions of United Aircraft Corporation.  Pending its receipt of Civil Aeronautics Board passenger route rights, it intended to purchase three VS-44As, whose names reflected its American Export shipping—and original—division of vessels—namely, "Excalibur," "Excambian," and "Exeter"—while Pan American itself ordered the competing Martin M-130 flying boat.

Several design modifications were first required to bring it up to commercial standard.  The nose turret, first and foremost, had to be replaced with a solid, rounded, cone made of metal, while the windows, doors, and hatches were relocated.  In order to transform the patrol bomber into an airliner, an altogether different interior had to be installed, bulkhead-divided into six smaller, watertight sections with appropriate passenger seating, galleys, lavatories, heating, ventilation, and soundproofing.  A larger horizontal tail, featuring ten degrees of dihedral, was retrofitted to augment longitudinal control, while aileron and tail cables were rerouted.

The interior configuration included a five-person cockpit controlled by a pilot, copilot, flight engineer, navigator, and radio operator; a galley located immediately below it and equipped with an oven, an electric stove with two hot plates, a sink, hot and cold water, a refrigerator, and storage cabinets; crew sleeping accommodations; mooring equipment; a baggage compartment; and two men's rooms.  Passenger capacity varied between 32 in day and 16 in sleeper configuration.  Forty-inch-wide seats were convertible into both upper and lower berths, and each was provided with a window, a reading light, and heating and ventilation vents.  The aft cabin contained the ladies' room, a second baggage compartment, and cabin crew accommodation.

Upon completion, the VS-44A, with a 79.3-foot overall length, sported a high, thick, 124-foot wingspan from which projected the four three-bladed, 12.6-foot-diameter propellers driven by 1,200-take off horsepower Pratt and Whitney Twin Wasp S13C-G piston engines and below which hung two, water surface-skimming floats near its wingtips.  Two dual-wheeled main beaching gear units and a single, twin-wheeled tail unit permitted nonaquatic ground taxiing.  The tailplane spanned 31 feet.  With a 3,820-gallon fuel capacity, the aircraft offered a 59,534-pound gross weight and a 211-mph maximum speed.

Draped in Navy camouflage livery, the first aircraft, named "Excalibur," was completed on December 30, 1941, but was redirected by the necessities of World War II.  AEA, operating it with its own flight crews, commenced weekly, war transport transatlantic service on June 20 to Faynes, Ireland.  "Excambian" and "Exeter" were delivered on May 4 and June 23.

Operating the world's first nonstop westbound transatlantic crossing on June 22, 1942, aircraft "Excalibur" flew from Faynes to New York in 25 hours, 40 minutes with 16 passengers aboard.

The airframe's service life, however, would span little more than three months.  Executing a long, water-purposing take off from Botwood, Newfoundland, on October 3, 1942, it attained a ten-foot altitude before settling back into the water.  Re-emerging, it angled into an excessive, 30-degree nose-high attitude, during which time it climbed to 35 feet, but subsequently barreled earthward, impacting with the ocean's surface and breaking apart.  Five of the 11 crew members and six of the 26 passengers perished.  Although the actual cause had never been pinpointed, it is believed that the pilot had attempted to use an excessive, drag-producing, take off procedure-deviating trailing edge flap setting.

Because the remaining two airframes had constituted the world's longest-range commercial types, able to fly 3,100-mile or greater sectors with full payloads, and because the war dictated the need for such transports, their ownership was transferred to the US government on January 26, 1943 for operation in the Navy's transoceanic passenger, cargo, and mail ferry service to the Caribbean and Europe.  American Export Airlines, under contract to them, continued to maintain and fly the aircraft.

Repainted in AEA's livery in January of 1945, the two VS-44As recommenced scheduled, civilian service in June, but a later merger with American Overseas Airlines (AOA) and the prevalence of war-sparked runway construction obviated their need, transatlantic routes now increasingly served by land planes, such as the Douglas DC-4.

The "Excambian" and "Exeter" were therefore acquired by Tampico Airlines from the War Assets Corporation on February 27, 1946, at which time they were subserviced to other carriers for charter operations.  But Tampico's own financial difficulties resulted in their onward sale to Skyways International the following April.

Hull-losing accidents, hitherto characteristic of the design's history, struck once again—and only four months after the acquisition, on August 15, 1947.  Attempting to land on the River Plata near Montevideo, Uruguay, during black of night, in nonexistent visual reference conditions and without updated altimeter settings, aircraft "Exeter," already overloaded, impacted with the water surface, shedding its hull plates and severing half of its left wing.  Flooded with gushing water, the aircraft sank, taking nine of the 12 souls on board with it.  Only "Excambian," one of the four XPBS-1 and VS-44A airframes, now remained.  Its longevity would usurp them all.

After Skyways' liquidation and intermediate ownership by Seaboard Commercial Finance Corporation, the Aviation Exchange Corporation acquired the aircraft with the intention of transporting cargo to the Amazon River, but its plan, upon reconsideration, was not economically viable.  As a result, Avalon Air Transport, which provided steamship-competitive air service on the 27-mile sector from Long Beach, California, to Catalina Island, acquired it on June 14, 1957, but relocated the engine controls to a position between the forward two cockpit seats; removed the flight engineer's panel, and rendered the navigator and radio operator functions redundant.  Seating capacity increased to 47.  Operating under an FAA supplemental type certificate, the single VS-44A ultimately made 8,172 trips to Catalina Island during its decade of service, carrying more than 211,000 passengers, along with 68 trips to San Clemente under Navy contract.

Continuing in this island-hopping role, the "Excambian" provided inter-Caribbean connections, particularly between St. Thomas and St. Croix, when Antilles Air Boats purchased it on January 9, 1968 for $100,000.  However, the short-lived operation, almost ending the way the lives of the other three airframes had, was abruptly cut short when the aircraft ran aground after landing in St. Thomas the following year.  Although there had been no injuries and little more than wet feet in the forward cabin, repair costs, particularly due to corrosion, proved prohibitive, and it therefore remained in situ for another six years.

With its service life thus effectively terminated, Antilles Air Boats donated the aircraft to the Naval Air Museum in Pensacola, Florida, in 1976, and they concluded a long-term loan agreement with the New England Air Museum in 1983.  During its subsequent, ten-year restoration, conducted in a temporary, $150,000 Rubb hangar at Sikorsky Memorial Airport in Stratford, it was transformed into its original, 1942, American Export Airlines configuration, requiring the replacement of 97 percent of its aluminum skins, 35 percent of its airframe structure, the relocation of the engine controls to the flight engineer's panel, and the installation of its transoceanic flying boat passenger cabin.

The project, under National Air and Space Museum guidance, was completed by a team of volunteers from Sikorsky, Textron Lycoming, the airline industry, and technical schools.

Relocated in sections, including the wings, engines, and control surfaces, to the Windsor Locks New England Air Museum, it was reassembled and painted in AEA livery during the latter half of the year before being displayed in its Harvey H. Lippincott Civil Aviation Hangar.

Having transported passengers, cargo, and mail in both military and commercial configurations for more than a quarter of a century, the latter entailing scheduled airline, charter, and air taxi operations, the "Excambian," the last of the remaining four XPBS-1 and VS-44A airframes, equally represents the end of the long-range, transoceanic, elegantly-appointed, flying boat era, and remains on display, dominating the hangar, to tell its story.

About the Author

US Auctions Australian Auctions Austrian Auctions Belgian Auctions Canadian Auctions French Auctions German Auctions Irish Auctions Italian Auctions Dutch Auctions Spanish Auctions Swiss Auctions GB Auctions

Best Match Items Ending First Newly-Listed Items First Price + Shipping: Lowest First Price + Shipping: Highest First

USC97C98C99C100AIRMAIL PLATE BLOCKSMINT NH $24.45 Time Remaining: 29d 5h 32m Buy It Now for only: $24.45 Buy It Now

US AIRMAILC3150C STAMP TRANSPORT BLK OF 10 WITH PLATE MNH OG BROOKMAN CV100 $24.50 (8 Bids) Time Remaining: 3h 2m

nystamps Mint Old US Air Mail Stamp Plate Block Collection $66.89 (15 Bids) Time Remaining: 4h 20m

USC46AIRMAIL PLATE BLOCKMINT NHVF $16.45 Time Remaining: 6d 4h 43m Buy It Now for only: $16.45 Buy It Now

Usa Scott C14 Graf Zeppelin PLATE SINGLE FORGERY REPRINT FAKE FAUX $6.90 (2 Bids) Time Remaining: 11h 39m

AIRMAIL PLATE BLOCKS $49.95 Time Remaining: 14d 1h 46m Buy It Now for only: $49.95 Buy It Now

CANADA 1930 Mercury 5c Airmail Plate Block C2 Mint VF NH $435.00 Time Remaining: 41m

CANADA 1950 Airmail 7c G Plate Block 2 Mint NH CO2 UL $75.00 Time Remaining: 44m

C23 ARROW PB 1938 6c AIRMAIL ISSUE PLATE F21844 21837 SCARCITYB MINT OG $12.00 Time Remaining: 9h 17m Buy It Now for only: $12.00 Buy It Now

CANADA 1950 Airmail 7c G Plate Block 1 Mint NH CO2 LR $75.00 Time Remaining: 44m

Scott C38 Plate Block 23846 1948 Airmail 5c FVF MNH Lower Left $5.25 Time Remaining: 17d 8h 10m Buy It Now for only: $5.25 Buy It Now

nystamps Large Mint US Air Mail Stamp Plate Block Collection $58.00 (10 Bids) Time Remaining: 3d 2h 21m

CANADA 1950 Airmail 7c G Plate Block 1 Mint NH CO2 UL $65.00 Time Remaining: 44m

Israel 1953 Jaffa Airmail MNH Single with Plate number Scott C16 $3.00 Time Remaining: 13d 4h 13m Buy It Now for only: $3.00 Buy It Now

12 USA 1940s AIRMAIL First Day COVERS SUPER CACHET S PLATE s LINE PAIR + + $6.25 (4 Bids) Time Remaining: 5h 51m

USC98C99C100AIRMAIL PLATE BLOCKSMINT NH $19.45 Time Remaining: 29d 5h 42m Buy It Now for only: $19.45 Buy It Now

1940s 50s US Large Beautiful Airmail Plate Block Collection 1st Bid Face Value $41.00 (4 Bids) Time Remaining: 1d 6h 24m

Scott 4531 40 Plate Block of 10 VF MNH Garden of Love $6.99 Time Remaining: 19d 9h 26m Buy It Now for only: $6.99 Buy It Now

USC29 AIRMAIL PLATE BLOCK1940SMINT NH $2.00 (4 Bids) Time Remaining: 3d 6h 11m

POPS STUFF 38 DIFFERENT AIRMAIL PLATE Blocks Mnh FACE VALUE 1916 $20.26 (6 Bids) Time Remaining: 11h 34m

USC118AIRMAILPLATE BLOCK OF 4MINT NH $5.75 Time Remaining: 25d 2h 30m Buy It Now for only: $5.75 Buy It Now

1 Scott Number C 8 MNH Plate Block of 6 $3.25 (2 Bids) Time Remaining: 12h 31m

SCOTT C47C56 C66 AIRMAIL PLATE BLOCKS of FOUR MINT NH SHIPS FREE $2.75 Time Remaining: 24d 58m Buy It Now for only: $2.75 Buy It Now

C46 VF XF OG NH Plate Block of 4 Bold Color pbc46g $19.00 Time Remaining: 4h 17m

POPS STUFF PB2 AIRMAIL PLATE BLOCK C46 HAWAII 80 CENTS MNH $7.00 (6 Bids) Time Remaining: 11h 20m

US SC C115 Transpacific Air Mail Fdc Plate Block Of 4 Uncacheted $3.50 Time Remaining: 29d 10h 28m Buy It Now for only: $3.50 Buy It Now

nystamps P Mint US Air Mail Stamp Plate Block Collection Album Page $36.67 (2 Bids) Time Remaining: 5d 6h 1m

USC8AIRMAIL PLATE BLOCKMINTVF $19.45 Time Remaining: 6d 4h 47m Buy It Now for only: $19.45 Buy It Now

1920s 1930s US Airmail Plate Block Collection M NH LOOK $15.50 (6 Bids) Time Remaining: 2d 4h 39m

US Air Mail plate blocks Less than Face $14.95 (1 Bid) Time Remaining: 2d 3h 32m

C32 MNH OG 1946 5c DC 4 SKYMASTER plate pair AIRMAIL VERY CLEAN CRISP $1.95 Time Remaining: 29d 10h 33m Buy It Now for only: $1.95 Buy It Now

C18 VF XF OG NH Large Top Fresh plate normal minor gum MORE pbb0025 $575.00 Time Remaining: 4h 17m

POPS STUFF PB1 AIRMAIL PLATE BLOCK C31 MNH $19.77 Time Remaining: 11h 39m Buy It Now for only: $19.77 Buy It Now

1956 USSR CHARKOW UKRAINE 40k NORTH POLE 1791 PLATE FLAW AIR MAIL to CSR $39.99 Time Remaining: 5h 40m

C23 AIRMAIL PLATE NUMBER PAIR FRANKLINPA JUN41939 $7.99 Time Remaining: 19d 4h 50m Buy It Now for only: $7.99 Buy It Now

USC12PLATE NUMBERAIRMAILMINT NH $4.99 (4 Bids) Time Remaining: 1d 6h 7m

3 Early MNH US Airmail Plate Blocks $4.25 (6 Bids) Time Remaining: 4d 12h 31m

1989 White Ace Supplement for Airmail Plate Blocks $6.95 Time Remaining: 15d 51m Buy It Now for only: $6.95 Buy It Now

9 MNH US Airmail Plate Blocks $2.25 (3 Bids) Time Remaining: 4d 12h 46m

USC128AIRMAILPLATE BLOCK OF 4MINT NH $6.45 Time Remaining: 25d 2h 31m Buy It Now for only: $6.45 Buy It Now

1 Scott number C 7 MNH Plate Block of 6 $6.10 (6 Bids) Time Remaining: 12h 36m

C10 LEFT SIDE PLATE BLOCK VF OG NH CAT 13000 JB NICE SHINY GUM $24.99 (1 Bid) Time Remaining: 3d 12h 13m

Israel 1960 Towns Airmail MNH Plate Block Set C18 C27 $12.00 Time Remaining: 26d Buy It Now for only: $12.00 Buy It Now

C 22 PLATE BLOCK 6 VF OG NH YEAR OF ISSUE 1937 $9.99 (1 Bid) Time Remaining: 3d 12h 10m

Scott 4529 Plate Block of 4 VF MNH Purple Heart 2011 $3.49 Time Remaining: 19d 9h 38m Buy It Now for only: $3.49 Buy It Now

C 20 PLATE BLOCK 6 FINE VF OG NH YEAR OF ISSUE 1935 $9.99 (1 Bid) Time Remaining: 3d 12h 11m

ScC59 ABRAHAM LINCOLN AIR MAIL PLATE BLOCK OF 4 MNH OG $0.99 (1 Bid) Time Remaining: 1h 12m

C32 Plate block 5cent DC4 Skymaster 4 engine Air mail $0.99 Time Remaining: 3d 1h 38m Buy It Now for only: $0.99 Buy It Now

Scott C 27 20C Air Transport Plate Number single MNHOG $1.99 Time Remaining: 23h 57m

C138 Plate block Air mail 60cnt Acadia National Park ME $7.75 Time Remaining: 12d 1h 34m Buy It Now for only: $7.75 Buy It Now

C114 MVFNH OG plate block of 4 Sperry Brothers $2.25 (1 Bid) Time Remaining: 22h 55m

2001 Mt McKinley #C137 Airmail Plate Block of 4 x 80 cents US Postage Stamps Sale Price: $4.50   Eligible for free shipping! Availability: Usually ships in 1-2 business days See Reviews For This Product Description On 5/20/2001 the USPS issued the fifth installment of the Scenic American Landscapes Series. Named for President William McKinley, Mount McKinley is located in Alaska's Denali National Park and Preserve...

1980 PHILIP MAZZEI #C98 Airmail Plate Block of 12 x 40 cents US Postage Stamps Sale Price: $5.80   Eligible for free shipping! Availability: Usually ships in 1-2 business days See Reviews For This Product Description On October 13, 1980 in Washington, DC., the USPS honored Italian-American patriot Philip Mazzei, who promoted American independence through his writings published in America and Europe during the 18th century...

1989 FRENCH REVOLUTION #C120 (airmail) Plate Block of 4 x 45 cents US Postage Stamps Sale Price: $12.00   Eligible for free shipping! Availability: Usually ships in 1-2 business days See Reviews For This Product

2001 NINE-MILE PRAIRIE #C136 Airmail Plate Block of 4 x 70 cents US Postage Stamps Sale Price: $3.94   Eligible for free shipping! Availability: Usually ships in 1-2 business days See Reviews For This Product Description In 2001 the USPS issued the fifth stamp in the Scenic American Landscape Series, displaying the sweeping tall grasses of the Nine Mile Prairie. Most of this 230acre prairie north of Lincoln, Nebraska, has never been plowed...

1980 GLEN CURTISS #C100 Airmail Plate Block of 12 x 35 cents US Postage Stamps Sale Price: $6.45   Eligible for free shipping! Availability: Usually ships in 1-2 business days See Reviews For This Product Description On December 30 1980 at Hammondsport NY., the USPS issued this 35 cent to honor early aviator and noted aircraft designer Glenn Curtiss. He is best remembered for hi design and production of the first successful seaplanes and amphibian airplanes, as well as various military planes

1959 PAN-AMERICAN GAMES #C56 Airmail Plate Block of 4 x 10 cents US Postage Stamps Sale Price: $0.85   Eligible for free shipping! Availability: Usually ships in 1-2 business days See Reviews For This Product Description On August 27, 1959 in Chicago, IL., the USPS issued this 10 cent airmail stamp to mark the opening of the Pan-American Games of 1959. It was issued in the airmail rate to Central and South America for use on such letters headed there.

1959 JUPITER BALLOON #C54 Airmail Plate Block of 4 x 7 cents US Postage Stamps Sale Price: $0.90   Eligible for free shipping! Availability: Usually ships in 1-2 business days See Reviews For This Product Description On August 17 1959 at Lafayette IN., the USPS commemorated the 100th anniversary of the first carriage of airmail in the United States on the hot-air balloon Jupiter. The balloon was flown by John Wise from Lafayette to Crawfordsville, Indiana, on August 17, 1859...

1980 BLANCHE STUART SCOTT #C99 Airmail Plate Block of 12 x 28 cents US Postage Stamps Sale Price: $4.95   Eligible for free shipping! Availability: Usually ships in 1-2 business days See Reviews For This Product Description On December 30,1980 in Hammondsport, NY., the USPS honored an aviation pioneer and the first American woman to fly solo. After her early flights, she joined a group of pilots on the daredevil circuit and earned the title "The Tomboy of the Air...